The most widely used mist eliminator in industrial applications is the knitted-wire-mesh type. These mesh eliminators consist of a pad of knitted wire mesh packed between two rigid grids for support. Liquid droplets accumulate on the wires, while vapor flows upward through the mesh pad. Gravity causes the liquid to drain from the mesh.
Advantages :
Based on your process requirements, we provide a recommended pad area derived from our hydraulic calculations.
We then design the optimal configuration to fit the separator's dimensions and achieve maximum efficiency.
These pads can be customized in circular, rectangular, cylindrical, or V-shaped forms.
Each pad is supplied with top and bottom grids and fixing hardware.
The following list summarizes some types of mesh mist eliminator designed and supplied by Ekaislot.
Vane Mist Eliminators
Specially profiled chevron style baffle plates are the secret of our vane mist eliminators. These mist eliminators remove liquid droplets from a vapor stream by the inertial impact of droplets with the baffle plate. Meanwhile, the gas follows a zigzag path between the baffles.
Vane mist eliminator provides higher capacity of handling gas load. Moreover, if vanes are installed in a horizontal flow instead of vertical gas flow, it can handle still higher gas velocities. It is less efficient in removing very small droplets compared to mesh type. Standard design is for removal of droplets larger than 30 µm, and we can propose special design of high efficiency for removal of droplets around 15 µm.
Features include:
No Drainage Channels
Open Drainage Channels (Single Pocket)
Enclosed Drainage Channels (Double Pocket)
Fouling resistance can be accommodated within the range.
Liquid/Liquid Separator :
ESP Plate Pack Coalescers
Liquid-Liquid separators are commonly employed to remove oil or other hydrocarbon components from water. Ekaislot can provide you the plate coalescer design to aid in coalescing oil droplets in the water and water droplets in the oil.If your process requires the separation of two or three phases, Coalescers perform very effectively.
Designed and manufactured for easy installation and removal for maintenance, Coalescers are well proven across many applications.
Liquid/Gas and Liquid/Liquid Separators
Our Separator Internals are designed based on established industry standards and feature unique mechanical enhancements to deliver reliable and efficient performance. Through rigorous modeling of separation efficiency and capacity, we optimize both equipment geometry and system properties, ensuring superior performance and reliability.
Feed diffuser is diverting the incoming flow from the inlet nozzle towards the reactor.
价格:
0.00
Liquid Distributor Tray
Liquid distributor tray ensures flow distribution over the entire vessel cross section.
价格:
0.00
Support Grid
The support grid serves as a catalyst retention device, spanning the entire cross-section of the vessel.
价格:
0.00
Outlet Collector
Outlet collector is collecting the flow from the reactor towards the outlet vessel nozzle.
价格:
0.00
Quench System
In multi-bed reactors, the process may require a cooling phase between two beds. This can be achieved by injecting a fluid, which is then collected, mixed, and redistributed over the subsequent bed.
价格:
0.00
Center Pipe
The center pipes inside the radial flow reactors are used for flow
collection or distribution. They are typically cylindrical, with the
outer layer defining the boundary of the catalyst bed.
During the design and manufacturing phases, we implemented control procedures to enhance process efficiency.
价格:
0.00
Scallops
The center pipes inside the radial flow reactors are used for flow collection or distribution. They are Scallops inside the radial flow reactors are for flow collection or distribution.
It is generally D-shape, extending parallel to the inner vessel wall,and its inner layer delimits the outer layer of the catalyst bed.
价格:
0.00
Outer Basket
Outer baskets inside the radial flow reactors are for flow collection or distribution.
It is concentric by center pipes and its layer delimits the outer layer of the catalyst bed.
价格:
0.00
Disc Filter
Disc filter is used in petrochemical industry,separating the solid residue from PTA. This reactor internal is the bottom filter of PTA hydrogenation reactor,being made of expensive Hastalloy C276. It can be applied under high temperature (350°C) and pressure (10MPA).
Polycrystalline silicon hydrogenation reactor internals is made of expensive 800H,which costs 8 million RMB. Ekaislot supplies exquisite welding technique as 800 H is rigid and wearable, being applied under high temperature and pressure.